Free
CLINICAL INVESTIGATION  |   December 1995
Where Are the Costs in Perioperative Care?: Analysis of Hospital Costs and Charges for Inpatient Surgical Care
Article Information
Airway Management / Ambulatory Anesthesia / Critical Care / Gastrointestinal and Hepatic Systems / Neurosurgical Anesthesia / Obstetric Anesthesia / Practice Management / Radiological and Other Imaging / Renal and Urinary Systems / Electrolyte Balance / Technology / Equipment / Monitoring / Quality Improvement
CLINICAL INVESTIGATION   |   December 1995
Where Are the Costs in Perioperative Care?: Analysis of Hospital Costs and Charges for Inpatient Surgical Care
Anesthesiology 12 1995, Vol.83, 1138-1144. doi:
Anesthesiology 12 1995, Vol.83, 1138-1144. doi:
Abstract

Background: Many health-care institutions are emphasizing cost reduction programs as a primary tool for managing profitability. The goal of this study was to elucidate the proportion of anesthesia costs relative to perioperative costs as determined by charges and actual costs.

Methods: Costs and charges for 715 inpatients undergoing either discectomy (n = 234), prostatectomy (n = 152), appendectomy (n = 122) or laparoscopic cholecystectomy (n = 207) were retrospectively analyzed at Stanford University Medical Center from September 1993 to September 1994. Total hospital costs were separated into 11 hospital departments. Cost-to-charge ratios were calculated for each surgical procedure and hospital department. Hospitalization costs were also divided into variable and fixed costs (costs that do and do not change with patient volume). Costs were further partitioned into direct and indirect costs (costs that can and cannot be linked directly to a patient).
Results: Forty-nine (49%) percent of total hospital costs were variable costs. Fifty-seven (57%) percent were direct costs. The largest hospital cost category was the operating room (33%) followed by the patient ward (31%). Intraoperative anesthesia costs were 5.6% of the total hospital cost. The overall cost-to-charge ratio (0.42) was constant between operations. Cost-to-charge ratios varied threefold among hospital departments. Patient charges overestimated resource consumption in some hospital departments (anesthesia) and underestimated resource consumption in others (ward).
Conclusions: Anesthesia comprises 5.6% of perioperative costs. The influence of anesthesia practice patterns on "downstream" events that influence costs of hospitalization requires further study.
MANY health-care institutions are emphasizing cost reduction programs as a primary tool for managing profitability. Services related to surgery can represent more than 40% of hospital costs and revenues.* Knowing the actual costs of providing care to surgical patients will assist hospital managers in developing targets for reduction and improving usage of health-care resources. 1Although reducing anesthesia costs may lead to savings, 2-8the relative contribution of anesthesia costs to total perioperative costs is uncertain. 9.
Analysts often use patient charges to approximate costs. 10-16The rationale behind this strategy involves:(1) hospital charges are more accessible than true costs; and (2) charges are believed to be related to costs by a constant correction factor--the cost-to-charge ratio. However, basing an economic analysis on charges alone is known to lead to misleading results. 17-19The goal of this study was to elucidate the proportion of anesthesia costs relative to the major hospital departments involved in surgical care and to explore the cost-to-charge relationship in perioperative care.
Methods and MaterialsSurgical ProceduresCost Data SourceTotal CostsAnesthesia CostsClassification of CostsVariable Direct CostsCost-to-charge RatiosStatistics and Data Management
This retrospective study was approved by the institution's Human Subjects Committee. We selected four in-patient surgical procedures:(1) intervertebral disc excision (discectomy);(2) retropubic or radical prostatectomy (prostatectomy);(3) appendectomy; and (4) laparoscopic cholecystectomy. These procedures were chosen because they represent common, nontertiary operations that may require a range of hospital resources.
We used International Classification of Diseases, 9th Revision, Clinical Modification (ICD-9-CM) procedure numbers 80.51 (discectomy, n = 234 patients), 60.4–60.5 (prostatectomy, n = 152 patients), 47.0 (appendectomy, n = 122 patients), and 51.23 (laparoscopic cholecystectomy, n = 207 patients) to retrieve hospital cost data for all 715 patients undergoing one of the four procedures between September 1993 and September 1994. Patients with other ICD-9-CM codes as principal procedures were excluded. Data were analyzed for each patient, by surgical procedure, and then in the aggregate for all patients. All patients underwent surgery at Stanford University Medical Center.
Cost data were obtained from Stanford's integrated hospital cost management and decision system software (Transition Systems Inc., Boston, MA; TSI). The TSI software was developed at the New England Medical Center in the 1980s and has been implemented in more than 100 hospitals in the United States and in Europe. The TSI system acquires data from the hospital's existing data management systems, including clinical and financial transactions systems.
The TSI system divides costs into various categories based on the information available in the hospital's information systems. Clinical and financial data are combined to determine actual supply costs, compensation rates, and labor effort as measured by hospital department managers. TSI cost standards are continuously tested for accuracy and calibrated to actual expenses and revenues. All labor costs (e.g., nursing, technician, house staff) are included except for physician professional fees.
The total hospital cost for each patient and for each operation was separated into 11 hospital departments: operating room, ward, surgery admission unit, post-anesthesia care unit, anesthesia, laboratory, pharmacy, intensive care unit, blood blank (blood), radiology, and miscellaneous. Operating room costs include all equipment, labor, and supplies used once the patient entered the operating room. Ward costs reflect nursing density and the room and board function of the patient ward. The miscellaneous category included costs of occupational and physical therapy, emergency room, ambulatory treatment unit, endoscopy, and dietary services. Using patient-specific data, detailed resource consumption profiles were established for each of the 11 hospital departments.
Anesthetics were delivered by staff anesthesiologists and anesthesia house staff. All medications and supplies used to anesthetize each patient were recorded and included in the "anesthesia" hospital department. Examples of these costs were all airway supplies (e.g., endotracheal tube), intravenous and blood administration supplies (e.g., blood pump intravenous tubing), invasive pressure monitoring (e.g., transducers), regional anesthesia supplies (e.g., epidural kit), and salaries of anesthesia technicians. The professional fees of anesthesiologists (and all other attending staff) were excluded. Fixed costs such as the depreciation of the anesthesia machine were also used to calculate total costs.
Variable and Fixed Costs. Total costs for each of the 11 hospital departments were separated into variable and fixed components. Variable costs change in direct proportion to volume; fixed costs remain unchanged despite changes in volume. 20.
Direct and Indirect Costs. Costs were also partitioned into direct and indirect components. Direct costs could be identified specifically with a patient care service. Indirect costs, conversely, are not directly related to individual patients but are incurred to support the clinical service.
Using the categories described earlier, costs were arranged into four subcategories: variable direct, variable indirect, fixed direct, and fixed indirect.
Variable direct costs were defined as labor and supplies directly involved in producing a specific patient service. Examples include operating room personnel and supply costs required to deliver an anesthetic or nursing labor and medical supply expenses used to produce a patient day with 6 h of nursing care. Variable direct costs may reflect costs controlled by physicians' clinical decision-making because neither fixed costs nor overhead costs are included in the variable direct cost category. The total variable direct cost attributed to a specific hospital unit (e.g., postanesthesia care unit) for a given patient was the sum of all the variable direct costs required to provide that service to the patient.
Variable Indirect Costs. Variable indirect costs were support costs driven by the level of service provided. Salaries for workers in Dietary or filing personnel in Medical Records are examples of variable indirect costs.
Fixed Direct and Indirect Costs. Fixed costs were allocated to the production of a patient service. Unit clerks and telephone expenses on nursing units are examples of fixed direct costs. Conversely, if a cost could not be linked with a particular patient, it was considered a fixed indirect cost (e.g., administration). As another example, a department's allocated depreciation expense was calculated from the square footage it occupied.
We also collected hospital bill charges for each patient. For each surgical procedure, an overall cost-to-charge ratio was calculated by dividing total hospitalization costs for all patients by the corresponding charges. Cost-to-charge ratios were also obtained for each of the 11 hospital departments.
Data management and calculations were performed on Excel 4.0. (Microsoft Corporation, Redmond, WA) The proportion of hospital costs accounted for by each department were calculated by dividing the sum of department (e.g., anesthesia) costs for all patients by the sum of each patient's total costs. Ninety-five percent confidence intervals (95% CI) for these proportions (ratio of mean values of two random variables) were obtained with Fieller's Theorem. 21Analysis of variance with the Bonferroni method was used to describe statistical significance for cost-to-charge ratios among hospital departments and for percentages of total departmental costs due to variable direct costs. 22Follow-up comparisons were performed with t tests. Cost and charge data for patients were compared using the Wilcoxon signed-rank test. Cost-to-charge ratios and variable direct cost to total cost percentages are presented as mean plus/minus one standard deviation.
ResultsTotal CostsDistribution of Total Costs by Hospital DepartmentCosts Versus ChargesOverall Cost-to-charge RatioCost-to-charge Ratios Vary Among Hospital DepartmentsPercentage of Total Cost that Are Variable Direct Costs
Variable direct costs accounted for 44% of the total cost of hospitalization. Fixed indirect cost were 38% of total costs and fixed direct costs accounted for 13% of total costs. The remaining 5% of costs were variable indirect costs.
When using actual cost data, intraoperative anesthesia costs as a percentage of the total hospital cost equaled 5.6%(plus/minus 0.7%, 95% CI plus/minus 1.4%). The largest hospital cost category was the operating room (33% plus/minus 0.2%, 95% CI plus/minus 0.4%). Costs attributed to the patient ward equaled 31%(plus/minus 0.1%, 95% CI plus/minus 0.2%). Postanesthesia care unit costs were 3.7%(plus/minus 0.96%, 95% CI plus/minus 2.0%) of the total perioperative cost. The relative contribution of each hospital department to total cost varied among procedures (1).

 Image not available

The ranking of the relative contribution of the hospital departments using charge data was similar to that for cost data. However, the actual percentages attributed to the hospital departments were different than when calculated with cost data. There was no consistent pattern to the differences.
Patient charges resulted in a 23% relative underestimate of the percentage of hospital resources utilized in delivering postoperative ward care (P < 0.001;2). In contrast, patient charges resulted in a 48% relative overestimate of actual anesthesia costs (P < 0.001;3). In absolute terms, charge analysis overestimated operating room costs as a fraction of total hospital costs for laparoscopic cholecystectomy (41.7% of total charges vs. 37.2% of total costs; P < 0.001). Charge analysis underestimated operating room costs for discectomy (33.6% of total charges vs. 39.2% of total costs; P < 0.001). For appendectomy and prostatectomy, charge data analysis resulted in negligible differences with actual cost analysis when estimating operating room costs as a fraction of total hospital costs.

 Image not available

 Image not available

Dividing all hospital costs by all patient charges produced an overall cost-to-charge ratio of 0.42 (plus/minus 0.01). Overall cost-to-charge ratios were constant among operations.
Cost-to-charge ratios for each hospital department were significantly different from each other (P < 0.001;1). Anesthesia had a cost-to-charge ratio of 0.29 (plus/minus 0.03).
Table 1. Cost-to-Charge Ratio Differs Significantly* by Hospital Department
Image not available
Table 1. Cost-to-Charge Ratio Differs Significantly* by Hospital Department
×
Direct costs were 64%(plus/minus 0.1%, 95% CI plus/minus 0.2%) of operating room costs and 48%(plus/minus 0.05%, 95% CI plus/minus 0.1%) of ward costs. Variable direct costs (costs affected by a physician's clinical decision-making) as a percentage of total departmental costs were significantly different among the hospital departments (P < 0.001;2). A higher ratio (variable direct cost/total costs) within a hospital department suggests lower fixed costs and greater likelihood that decreased utilization of resources within a department will result in substantial decreases in total departmental costs. Forty-four percent of total anesthesia costs were variable direct costs.
Table 2. Percentage* of Hospital Departmental Costs Due to Variable Direct Costs
Image not available
Table 2. Percentage* of Hospital Departmental Costs Due to Variable Direct Costs
×
DiscussionAnesthesia CostsHospital Cost StructureCosts Versus ChargesFuture StudiesLimitations
To reduce perioperative inpatient costs, hospital managers need to know the principal determinants of costs. Assuming that hospital departments with the largest proportion of costs have the highest potential for cost reduction, reduction of operating room and patient ward costs is likely to yield the largest cost gains for surgical inpatients. At our institution, relying on charge data alone may misrepresent the true magnitude of costs within a hospital department.
Because charges may not accurately reflect true costs, a more precise understanding of costs is required for proper decision-making, management of quality of care and outcomes, cost control, and negotiation of viable capitated rates. For anesthesia, physician capitation rates for hospital-based care range from 8 to 10% whereas if the plan covers all medical care then the provider capitation rate for anesthesiologists is 3–5%.***** We estimate that intraoperative anesthesia hospital costs constitute 5.6% of the total hospital cost of an inpatient surgical procedure. The true fraction of resources consumed due to anesthesiology practice decisions is likely greater. This is because some costs outside the operating room (e.g., preoperative laboratory testing) were not allocated to "anesthesia" but may have been due to decisions related to anesthesia care. 23.
We found that half of the intraoperative anesthesia costs are variable direct costs. The greatest cost savings occur if interventions address variable costs (e.g., intravenous supplies). 24Choosing less costly alternatives can reduce such costs as long as the quality of care is not decreased. 25Thus, the lower bound of costs (e.g., anesthesia drugs, intubation supplies) under immediate control of anesthesia providers is approximately 3% of inpatient surgical costs. Although the cost per case of anesthesia resources is small, given the volume of anesthetics administered, small savings per case have represented substantial savings when aggregated. 3-6.
Our results suggest that approximately one third of total operating room costs and one half of patient ward costs are indirect costs used to maintain clinical support services (e.g., Medical Records). In other words, costs associated with Medical Records, for instance, are shifted to billable clinical services such as the operating room. Varying cost-to-charge ratios (from 0.29 to 0.91 at our institution) for different hospital cost centers may reflect attempts to achieve reasonable profit margins and to use collections from a revenue-producing department to support non-revenue-producing hospital functions. Hospital operations improvement efforts that optimize efficiencies of hospital support functions will reduce perioperative costs by reducing indirect costs. In fact, attaining the targeted level of savings from operating room restructuring, for instance, may be compromised by the large (one third) indirect component of the total cost of running an operating room.
Charge data should be used cautiously in economic analyses because there is no fixed relationship between true economic costs and charges. 17-19The reason for this may be that charges have historically relied on comparisons with competing hospitals' charges and on imprecise internal costs. Prior to implementation of Medicare's prospective payment system in 1983, the Medicare Cost Report was the main approximation of cost accounting in most hospitals. An example of where charge data might be appropriate is in outpatient care in which the patient pays "out of pocket."
The calculated overall cost-to-charge ratio (0.42) was consistent across operations. Therefore, relative total charges may be a reasonable proxy for relative total costs. In other words, if two patients underwent the same procedure and the first patient had twice the total charges of the second patient, then on average the first patient had twice the total costs of the second patient. However, as hospital payment methods have changed, more accurate and precise cost management requires hospital cost accounting systems to specifically measure all inputs necessary for patient care. 26For our institution, had we only inspected patient charges as a proxy for hospital resources, we would have obtained misleading results about the proportions of costs, particularly, for the patient ward and for anesthesia.
Using cost data we found that 31% of hospital costs for radical prostatectomy was for operating room and anesthesia and 5% was for pharmacy. This is in contrast to a study of patients undergoing radical prostatectomy, which reported that 53% of the hospital charges was for the operating room and anesthesia while 16% was attributed to pharmacy. 15Differences in local medical practice patterns may also affect the distribution of costs and charges for a particular procedure.
Differences in charge and costing methods (e.g., how resources are assigned to a hospital department) can influence the economic evaluation of a procedure. Depending on how variable and fixed costs are defined, cost differences between surgical procedures can vary significantly. 19In this study, operating room personnel costs were considered as variable direct costs. However, if a patient does not arrive for their surgery, the personnel still must be paid. If this occurred, total costs would not change, but this labor cost could be allocated to a different cost category (e.g., variable indirect).
Future studies should focus on how the practice pattern and productivity of the anesthesiologist affects other cost factors--operating room efficiency, length of patient hospital stay, postoperative care requirements (e.g., intensive care unit vs. patient ward), and clinically important outcomes. For example, anesthesiologists may not be able to affect postanesthesia care unit costs to a great extent because the major determinant of postanesthesia care unit costs is the distribution of admissions. 27The effects of changing the way perioperative care is delivered (e.g., clinical pathways) on fixed and variable hospital costs deserves further study.
This study was performed in a single university hospital using a well-known cost accounting application (TSI). The results are not necessarily transferable to other institutions with other cost taxonomies. Nevertheless, the proportions of hospital departmental costs are likely to be generalizable to other hospitals. We did not evaluate ambulatory procedures, which are an important segment of surgical volume in the United States.
Anesthesia costs are a small portion of the overall costs associated with a surgical patient's hospital encounter. Our design could not evaluate the influence of physician practice patterns on "downstream" events in the hospitalization, some of which may have substantial economic impact (e.g., enhanced pain control in high-risk patients who experience fewer postoperative adverse events). Greater cost savings may come with improving operating room efficiency as well as those processes of care that reduce length of hospital stay (while maintaining similar or improved quality of care). This would seem more important than restriction of anesthesia agents, supplies, and equipment. More studies are needed on how anesthesiologists can promote more-cost efficient perioperative care by balancing economic pressures and the ability to deliver high quality medical care.
The authors thank Don Stanski M.D. (Department of Anesthesia, Stanford University School of Medicine) for his continuous encouragement, advice, and support of this research project.
*Rutter T, Brown A: Contemporary operating room management. Advances in Anesthesia 11:173–214, 1994.
**Personal communication, R. Miller, M.D., 3/11/95.
***Arens J: Negotiating with managed care contract holders. American Society of Anesthesiologists 1994 Annual Refresher Course Lectures. 236A:1–4, 1994.
REFERENCES
Hudson R, Friesen R: Health care "reform" and the costs of anesthesia. Can J Anesth 40:1120-1125, 1993.
Macario A, Chang P, Stempel D, Brock-Utne J: A cost analysis of the laryngeal mask airway for adult elective outpatient anesthesia. ANETHESIOLOGY 83:250-257, 1995.
Becker K, Carrithers J: Practical methods of cost containment in anesthesia and surgery. J Clin Anesth 6:388-399, 1994.
Hawkes C, Miller D, Martineau R, Hull K, Hopkins H, Tierney M: Evaluation of cost minimization strategies of anesthetic drugs in a tertiary care hospital. Can J Anesth 41:894-901, 1994.
Johnstone R, Jozefczyk K: Costs of anesthetic drugs: Experiences with a cost education trial. Anesth Analg 78:766-771, 1994.
Szocik J, Learned D: Impact of a cost containment program on the use of volatile anesthetics and neuromuscular blocking drugs. J Clin Anesth 6:378-382, 1994.
Broadway P, Jones J: A method for costing anesthetic practice. Anaesthesia 50:56-63, 1995.
Macario A, Brock-Utne: Elimination of 12 and 24 Fr esophageal stethoscopes from anesthesia practice: An attempt at cost containment (letter). Anesth Analg 79:393, 1994.
Johnstone R, Martinec C: Costs of anesthesia. Anesth Analg 76:840-848, 1993.
Behnia R, Hashemi F, Stryker S, Ujiki G, Poticha S: A comparison of general versus local anesthesia during inguinal herniorrhaphy. Surg Gynecol Obstet 174:277-280, 1992.
Bredenkamp J, Abemayor E, Wackym P, Ward P: Tonsillectomy under local anesthesia: a safe and effective alternative. Am J Otolaryngol 11:18-22, 1990.
Riley E, Cohen S, Macario A, Desai, Ratner E: Spinal versus epidural anesthesia for Cesarean section: A comparison of time efficiency, costs, charges, and complications. Anesth Analg 80:709-712, 1995.
Todd M, Warner D, Sokoll M, Matkabi M, Hindman B, Scamman F, Kirschner J: A prospective, comparative trial of three anesthetics for elective supratentorial craniootomy: Propofol/fentanyl, isoflurane/nitrous oxide, and fentanyl/nitrous oxide. ANETHESIOLOGY 78:1005-1020, 1993.
Yeager M, Glass D, Neff R, Brinck-Johnsen T: Epidural anesthesia and analgesia in high risk surgical patients. ANETHESIOLOGY 66:729-736, 1987.
Koch M, Smith J, Hodge W, Brandell R: Prospective development of a cost-efficient program for radical retropubic prostatectomy. Urology 44:311-318, 1994.
Hardy K, Miller H, McNeil, Shulkes: Measurement of surgical costs: a clinical analysis. Aust N Z J Surg. 64:607-611, 1994.
Orkin F: Moving toward value-based anesthesia care. J Clin Anesth 5:91-98, 1993.
Finkler S: The distinction between cost and charges. Ann Intern Med 96:102-109, 1992.
Hlatky M, Lipscomb J, Nelson C, Califf R, Pryor D, Wallace A, Mark D: Resource use and cost of initial coronary revascularization. Circulation 82(suppl IV):IV-208-IV-213, 1990.
Horngren C, Foster G: Cost Accounting: A Managerial Emphasis. Englewood Cliffs, Prentice-Hall, 1987, pp 39-40.
Kotz S, Johnson N: Encyclopedia of Statistical Sciences. Volume 3. New York, John Wiley & Sons, 1988, pp 87-88.
Glantz S: Primer of Biostatistics. 3rd edition. New York, McGraw Hill, 1992.
Macario A, Roizen M, Thisted R, Kim S, Orkin F, Phelps C: Reassessment of preoperative laboratory testing has changed the test-ordering patterns of physicians. Surg Gynecol Obstet 175:539-547.
Vitez T: Principles of cost analysis. J Clin Anesth 6:357-363, 1994.
Macario A: A health policy perspective on costs of short-term anesthesia services (letter). J Clin Anesth 7:175, 1995.
Chian Y: Improving hospital cost accounting with activity based costing. Health Care Manage Rev 18:71-77, 1993.
Dexter F, Tinker J: Analysis of strategies to decrease post-anesthesia costs. ANETHESIOLOGY 82:94-101, 1995.
Table 1. Cost-to-Charge Ratio Differs Significantly* by Hospital Department
Image not available
Table 1. Cost-to-Charge Ratio Differs Significantly* by Hospital Department
×
Table 2. Percentage* of Hospital Departmental Costs Due to Variable Direct Costs
Image not available
Table 2. Percentage* of Hospital Departmental Costs Due to Variable Direct Costs
×