Free
Correspondence  |   September 1999
Crimping of a Laser Tube Resulting in Hypoxemia 
Author Notes
  • Assistant Professor of Anesthesiology
  • Assistant Professor of Anesthesiology
  • Assistant Professor of Anesthesiology
  • Attending Anesthesiologist
  • Miami VAMC/University of Miami
  • Miami, Florida
Article Information
Correspondence
Correspondence   |   September 1999
Crimping of a Laser Tube Resulting in Hypoxemia 
Anesthesiology 9 1999, Vol.91, 898. doi:
Anesthesiology 9 1999, Vol.91, 898. doi:
To the Editor:
—Laryngeal surgery involving a laser often necessitates the use of special endotracheal tubes (ETTs) to avoid an airway fire. 1,2 Many companies, including Rüsch (Duluth, GA), manufacture these tubes. We describe an anesthetic complication with a laser ETT constructed from rubber, wrapped with foil, and overwrapped with fabric. 3 
The patient was a 90-kg, 170-cm, 65-yr-old male smoker who was scheduled for direct laryngoscopy and vocal cord laser therapy. After uneventful induction of general anesthesia and paralysis, the patient was intubated via  direct laryngoscopy with a 6.0-mm ID Rüsch Lasertubus (lot #CE0124) without difficulty. The patient had bilateral clear breath sounds, arterial oxygen saturation was 100%, and end-tidal CO2was demonstrated. The ETT was secured with 1-inch silk tape at 23 cm at the lips. The operating room table was then turned away from the anesthesia machine, and the surgeons extended the neck and head to position the patient for the surgical procedure. Within 30 s, the peak inspiratory pressures began to increase, and both the ETCO2and SpO2started to decrease. No devices had been inserted into the patient's mouth, and there was no tension on the circuit or ETT. The patient's head was returned to the neutral position, but bilateral auscultation showed minimal to no breath sounds bilaterally. The patient was hand-ventilated with 100% oxygen, and the sevoflurane was increased to 8%. SpO2decreased to 70%, and no ETCO2was evident by capnography. Immediate direct laryngoscopy confirmed correct ETT placement. Because inspection of the ETT showed no kinks or obvious obstructions, working diagnoses included the presence of either bronchospasm or a mucus plug in the tube. The patient received an inhaled β-agonist and subcutaneous terbutaline without improvement. We attempted to pass a suction catheter through the tube but met resistance at approximately 20 cm. Because initial intubation was easy and the patient was not responding to medical therapy, we decided to exchange the ETT for a PVC Portex (Keane, New Hampshire) Softseal 7.0-mm ID (nonlaser tube), which was inserted to 23 cm. Ventilation was achieved, and within 10 breaths, the patient's SpO2returned to 100%. Surgery proceeded, and it was decided that the laser portion of the operation was not necessary. Emergence and extubation were uneventful.
We inspected the Lasertubus and found the tube crimped under the tape (fig. 1). Although this was only a small defect not obvious to cursory inspection, it resulted in complete obstruction to airflow when tested with the breathing circuit. Experimenting with unused tubes showed that after bending the Lasertubus, a weakness within the wall of the tube remained, predisposing to crimping with minimal force and complete obstruction to airflow. All anesthesia providers need to be aware of this potential complication.
Fig. 1. (  Top  ) An unused 6.0 Rüsch laser ETT. (  Bottom  ) The 6.0 Rüsch ETT from our patient. The arrow points to the defect. 
Fig. 1. (  Top  ) An unused 6.0 Rüsch laser ETT. (  Bottom  ) The 6.0 Rüsch ETT from our patient. The arrow points to the defect. 
Fig. 1. (  Top  ) An unused 6.0 Rüsch laser ETT. (  Bottom  ) The 6.0 Rüsch ETT from our patient. The arrow points to the defect. 
×
References 
References 
Sosis M: Anesthesia for laser surgery. Anesth Clin North Am 1995; 13: 725–43
Rampil IJ: Anesthesia for laser surgery, Anesthesia, 4th Edition. Edited by Miller RD. New York, Churchill Livingstone, 1994.
Sosis MS, Kelanic S, Caldarelli D: An in vitro  evaluation of a new laser resistant endotracheal tube: The Rüsch Lasertubus (abstract). A NESTHESIOLOGY 1997; 87: A483
Fig. 1. (  Top  ) An unused 6.0 Rüsch laser ETT. (  Bottom  ) The 6.0 Rüsch ETT from our patient. The arrow points to the defect. 
Fig. 1. (  Top  ) An unused 6.0 Rüsch laser ETT. (  Bottom  ) The 6.0 Rüsch ETT from our patient. The arrow points to the defect. 
Fig. 1. (  Top  ) An unused 6.0 Rüsch laser ETT. (  Bottom  ) The 6.0 Rüsch ETT from our patient. The arrow points to the defect. 
×