Free
Clinical Science  |   December 1999
Efficiency of a New Fiberoptic Stylet Scope in Tracheal Intubation 
Author Affiliations & Notes
  • Takayuki Kitamura, M.D.
    *
  • Yoshitsugu Yamada, M.D., Ph.D.
  • Hong-Lin Du, M.D., Ph.D.
  • Kazuo Hanaoka, M.D., Ph.D.
    §
  • *Clinical and Research Fellow, Surgical Center, The Institute of Medical Science. †Associate Professor, Surgical Center, The Institute of Medical Science. ‡Visiting Assistant Professor, Department of Anesthesiology, Faculty of Medicine. §Professor and Chairman, Department of Anesthesiology, Faculty of Medicine.
Article Information
Clinical Science
Clinical Science   |   December 1999
Efficiency of a New Fiberoptic Stylet Scope in Tracheal Intubation 
Anesthesiology 12 1999, Vol.91, 1628. doi:
Anesthesiology 12 1999, Vol.91, 1628. doi:
FAILED or difficult tracheal intubation is an important cause of morbidity and mortality during anesthesia. The most common factor preventing successful tracheal intubation is the inability to see the vocal cords during direct laryngoscopy. A number of devices are available to circumvent the difficult airway problems typically encountered with conventional direct laryngoscopy. These airway devices include flexible fiberoptic bronchoscopes, the rigid optical stylet, light wands, rigid fiberscopes, such as the UpsherScope (Upsher Laryngoscope Corp., Foster City, CA), the Bullard laryngoscope (Circon ACMI, Stamford, CT), the Augustine Scope (Augustine Medical Inc. Eden Prairie, MN), and a visualized endotracheal tube. Although these devices have been used as adjuncts to facilitate difficult tracheal intubation, many necessitate the use of a specific video system, do not allow manual control of the flexion of the fiberoptic tip, and necessitate time-consuming preparation and an external light source, or both. 1–5 To improve the usefulness of available devices, we designed a fiberoptic stylet scope (FSS) that enables us to guide the endotracheal tube (ETT) into the trachea using visual control, requires short time to prepare, and does not need an external light source. The FSS is a simple form of a standard stylet, with the functional maneuverability and control of its tip and fiberoptic cables in the body. The intubation procedure is performed in the usual manner without compromising the view of direct laryngoscopy, while the view of the airway from the tip of the ETT can be controlled manually because of the FSS tip flexion.
The current study was undertaken to prospectively assess the efficiency of the FSS as an intubating tool.
Materials and Methods 
Device 
The diagram of the FSS (StyletScope, NihonKoden Corp., Tokyo, Japan) is shown in figure 1. Instead of glass fibers, the FSS uses a plastic fiberoptic imaging system incorporated directly into an endotracheal tube stylet (diameter, 6.0 mm). The FSS can be used with an ETT with an internal diameter of 7.0 mm or larger. The FSS consists of a flexing element made of two 2.0-mm malleable metal plates, a 1.0-mm-diameter plastic fiberoptic image guide embedded in an illumination fiberoptic bundle to form a lightweight intubation stylet. The proximal handle of the stylet carries a connector that fits to the 15-mm ETT adapter. The image guide is 3,500 pixels with an attached lens. The lens has a 50-mm focal length and a 50° field of view. An eyepiece is mounted on the handle of the scope. By depressing the lever attached to the proximal handle, the distal tip of the stylet, together with the ETT, can be flexed 75° anteriorly to provide direct access to anterior airways. A light source is built-in to the stylet handle and powered by two 1.5-V alkaline batteries. The FSS is reusable and can be sterilized using ethylene oxide.
Fig. 1. The new fiberoptic stylet scope (FSS), StyletScope. (  A  ) Diagram of the new FSS. By depressing the lever of the proximal handle, the distal tip of the stylet, together with the endotracheal tube, can be flexed 75°(  B  ). 
Fig. 1. The new fiberoptic stylet scope (FSS), StyletScope. (  A  ) Diagram of the new FSS. By depressing the lever of the proximal handle, the distal tip of the stylet, together with the endotracheal tube, can be flexed 75°(  B  ). 
Fig. 1. The new fiberoptic stylet scope (FSS), StyletScope. (  A  ) Diagram of the new FSS. By depressing the lever of the proximal handle, the distal tip of the stylet, together with the endotracheal tube, can be flexed 75°(  B  ). 
×
Technique 
The FSS is inserted into an ETT and locked with the stylet connector to the endotracheal tube adapter, preventing rotational and longitudinal displacement. The proper position of the stylet tip is just proximal to the bevel of the ETT, and it can be adjusted by sliding the connector within the housing. An antifog agent (Lens Cleaner, Olympus Japan, Tokyo, Japan) was lightly applied to the tip of the FSS using a clean gauze. Before the start of the intubation procedure, the FSS should be quickly checked for correct view and function. While the tongue is lifted using a standard laryngoscope blade, the ETT with the FSS is inserted into the mouth (fig. 2). The view of the epiglottis can be obtained directly behind the tongue. After the tip of the ETT has passed the epiglottis, if the direct view of the laryngeal aperture is not obtained instantaneously, the lever of the FSS can be gently depressed to bend the ETT anteriorly. In most cases, this maneuver resulted in orientation of the ETT tip toward the opening between the vocal cords, and the ETT can be inserted easily during direct visual control (the view is shown in fig. 3).
Fig. 2. Tracheal intubation procedure. After lifting the tongue using a standard laryngoscope blade, tracheal intubation is performed with the glottic opening viewed only by the fiberoptic stylet scope. 
Fig. 2. Tracheal intubation procedure. After lifting the tongue using a standard laryngoscope blade, tracheal intubation is performed with the glottic opening viewed only by the fiberoptic stylet scope. 
Fig. 2. Tracheal intubation procedure. After lifting the tongue using a standard laryngoscope blade, tracheal intubation is performed with the glottic opening viewed only by the fiberoptic stylet scope. 
×
Fig. 3. A view of the glottic opening through the fiberoptic stylet scope (FSS). This photograph was taken using a charge-coupled device camera attached to the eyepiece of the FSS. 
Fig. 3. A view of the glottic opening through the fiberoptic stylet scope (FSS). This photograph was taken using a charge-coupled device camera attached to the eyepiece of the FSS. 
Fig. 3. A view of the glottic opening through the fiberoptic stylet scope (FSS). This photograph was taken using a charge-coupled device camera attached to the eyepiece of the FSS. 
×
Study Protocol 
After obtaining approval from the Ethics Committee for Research of the Institute of Medical Science, the University of Tokyo, and the informed consent from each patient, we studied 32 consecutive patients undergoing general surgery who required oral tracheal intubation. Exclusion criteria from enrollment were age younger than 18 or older than 85 yr, American Society of Anesthesiologists (ASA) physical status IV, presence of coronary heart disease, cerebrovascular disease, or respiratory tract disease, and the known risk of regurgitation–aspiration (e.g.  , hiatal hernia, esophageal reflux, peptic ulcer, or not having fasted). During the preoperative visit, the Mallampati test, as modified by Samsoon and Young, 6 was performed by asking each patient to maximally protrude the tongue from a fully open mouth while sitting upright. During induction of anesthesia, the thyromental distance and the interincisor distance were measured. The thyromental distance was described as a straight line from the thyroid notch to the lower border of the mentum with the head extended.
Patients were premedicated with 0.01 mg/kg atropine sulfate and 0.5 mg/kg hydroxyzine. Routine monitoring, including electrocardiography, pulse oximetry, capnography, and noninvasive blood pressure monitoring, was performed before induction. The lungs of all patients were preoxygenated for 2 min and 2.0 μg/kg fentanyl was administered intravenously. Propofol, 1.0 mg/kg, was administered over 20 s and subsequently infused at a rate of 10 mg · kg−1· h−1. After adequate mask ventilation with 100% oxygen was ensured, 0.15 mg/kg vecuronium was administered to facilitate tracheal intubation.
With the patient's head and neck in the neutral position, a standard Macintosh laryngoscope (blade No. 3) was used only to elevate the tongue. Gentle traction force was exerted on the laryngeal soft tissues without attempting direct visualization of the glottic opening. At this time, the patient's laryngeal structures were inspected and graded according to Cormack and Lehane. 7 The intubation was completed, with the glottic opening being viewed only through the FSS (fig. 3). All intubations were performed by a 3-yr resident in anesthesiology (T.K.) who had no experience with the FSS but had received brief instruction regarding the use of the FSS before the study.
Times necessary for tracheal intubation were recorded, beginning at the moment of insertion of the laryngoscope into the mouth until the time when the FSS was removed from the ETT. The following data were recorded: age, weight, height, sex, potential, or known airway difficulty. Heart rate, blood pressure, and SpO2were recorded before induction of anesthesia, before starting intubation, and immediately after intubation.
Statistics 
Results are expressed as the mean ± SD. The time necessary for intubation among the groups divided according to the classes of Mallampati was compared using one-way analysis of variance. A comparison between the first five and last five patients was performed using an unpaired t  test. A P  value < 0.05 was considered significant.
Results 
Mean age, height, and weight were 57 yr (range, 39–81 yr), 161 cm (range, 142–178 cm), and 56 kg (range, 39–77 kg), respectively. The male:female ratio was 14:18. Airway variables are shown in table 1. Because we used a standard laryngoscope only to elevate the tongue, all patients were graded as Cormack grade III, indicating that only the epiglottis could be visible by direct laryngoscopy. In this condition, tracheal intubation using the FSS was successful during the first attempt in all patients except for two (the success rate during the first attempt, 94%). The second attempt was successful in these two patients (6%). The reasons for failure during the first attempt were mucous secretions on the lens in one instance and insufficient visualization of the glottic opening caused by the lack of space behind the epiglottis in the other. The mean time necessary for the intubation procedure was 29 ± 14 s in all patients, and 30 ± 15 s, 22 ± 7 s, and 32 ± 19 s in the patients classified as Mallampati class I, II and III, respectively (fig. 4). There was no significant difference (P  = 0.64) between the time necessary for the intubation procedure for the first five patients (33 ± 8 s) and that for the last five patients (29 ± 14 s).
Table 1. Variables Concerning the Difficult Airway 
Image not available
Table 1. Variables Concerning the Difficult Airway 
×
Fig. 4. Comparison of the time necessary for tracheal intubation using the new fiberoptic stylet scope among the groups divided according to the classes of Mallampati. There is no significant difference among the three groups. 
Fig. 4. Comparison of the time necessary for tracheal intubation using the new fiberoptic stylet scope among the groups divided according to the classes of Mallampati. There is no significant difference among the three groups. 
Fig. 4. Comparison of the time necessary for tracheal intubation using the new fiberoptic stylet scope among the groups divided according to the classes of Mallampati. There is no significant difference among the three groups. 
×
All patients were hemodynamically stable and SpO2was maintained above 98% throughout the intubation procedure. There were no adverse airway events during intubation. Neither major soft tissue damage nor dental trauma occurred, as determined by oral examination after intubation and by postoperative questioning. The incidence of minor sore throat and minor hoarseness on the first day after operation was 28 and 25%, respectively. No patient suffered from sustained hoarseness or laryngeal damage.
Discussion 
This prospective study showed that the FSS enables simple, reasonably rapid, gentle intubation. The rate of successful intubation was 94% on the first attempt and all patients in whom the first attempt was unsuccessful were successfully intubated on the second attempt.
Many commercially available airway devices necessitate the use of a specific video system, do not allow manual control of the flexion of the fiberoptic tip, and need time-consuming preparation and an external light source, or both. 1–5 The FSS, with its flexible plastic fiberoptic image system incorporated into the ETT stylet, can be flexed 75° anterior using the built-in light source and lightweight. It enables visualization of laryngeal structures and the trachea during the entire intubation procedure. During visual control viewed from the tip, the ETT can be directed at and passed through the glottic opening by maneuvering the tip when direct laryngeal exposure using a common laryngoscope blade is inadequate. In comparison, many other airway devices that directly view the glottis (e.g.  , UpsherScope) lack this maneuverability and force the patients upper airway anatomy to conform to the particular shape of the laryngoscope blade. 1 Although the image quality of the FSS appears to be inferior to the glass fiberscopes using 5,000 to 10,000 pixels in clinical practice, our experience indicates that it is clear enough for a successful intubation (fig. 3).
Other advantages of the FSS include necessitation of only little preparation time, prompt recognition and confirmation of tracheal placement of the tube, and simplicity of the intubation technique without the need for special training. The operator of the FSS in this study did not undergo preliminary training specific to the FSS technique before the study. There was no significant difference between the time necessary for intubation of the first five patients and the last five patients in this study.
Changes in hemodynamics were well within acceptable ranges and arterial blood was maintained fully saturated throughout the intubating procedure. No trauma associated with the procedure was observed in this study. Although no patient had sustained hoarseness or laryngeal damage, the incidence of minor sore throat and minor hoarseness on the first day after operation were 28 and 25%, respectively. These incidences are comparable to those in the patients intubated using usual direct laryngoscopy (50%). 8 
This study was conducted in a simulated difficult airway with Cormack grade III. Although this simulation may not be equivalent to a truly difficult airway, the FSS might be useful in the event of a difficult airway. There are several potential limitations with the FSS. Similar to fiberoptic intubation, intubation with the FSS might become difficult in patients with heavy secretions or gross blood in their airways. Secretions or blood in the oropharynx should be removed by airway suction during standard laryngoscopy before attempting intubation with the FSS. In addition, nasal intubation is impractical using the FSS.
In conclusion, intubation using the FSS proved to be a simple and effective technique for airway management.
References 
References 
Fridrich P, Frass M, Krenn CG, Weinstabl C, Benumof JL, Krafft P: The UpsherScopeTM in routine and difficult airway management: A randomized, controlled clinical trial. Anesth Analg 1997; 85: 1377–81
Cooper SD, Benumof JL, Ozaki GT: Evaluation of the Bullard laryngoscope using the new intubating stylet: Comparison with conventional laryngoscopy. Anesth Analg 1994; 79: 965–70
Krafft P, Krenn CG, Fitzgerald RD, Pernerstorfer T, Fridrich P, Weinstabl C: Clinical trial of a new device for fiberoptic orotracheal intubation (Augustine ScopeTM). Anesth Analg 1997; 84: 606–10
Katz RL, Berci G: The optical stylet? A new intubation technique for adults and children with specific reference to teaching. A NESTHESIOLOGY 1979; 51: 251–4
Weiss M: Video-intuboscopy: A new aid to routine and difficult tracheal intubation. Br J Anaesth 1998; 80: 525–7
Samsoon GLT, Young JRB: Difficult tracheal intubation: A retrospective study. Anaesthesia 1987; 42: 487–90
Cormack RS, Lehane J: Difficult tracheal intubation in obstetrics. Anaesthesia 1984; 39: 1105–11
Alexander CA: Incidence of sore throat with the laryngeal mask (letter). Anaesthesia 1989; 44: 791
Fig. 1. The new fiberoptic stylet scope (FSS), StyletScope. (  A  ) Diagram of the new FSS. By depressing the lever of the proximal handle, the distal tip of the stylet, together with the endotracheal tube, can be flexed 75°(  B  ). 
Fig. 1. The new fiberoptic stylet scope (FSS), StyletScope. (  A  ) Diagram of the new FSS. By depressing the lever of the proximal handle, the distal tip of the stylet, together with the endotracheal tube, can be flexed 75°(  B  ). 
Fig. 1. The new fiberoptic stylet scope (FSS), StyletScope. (  A  ) Diagram of the new FSS. By depressing the lever of the proximal handle, the distal tip of the stylet, together with the endotracheal tube, can be flexed 75°(  B  ). 
×
Fig. 2. Tracheal intubation procedure. After lifting the tongue using a standard laryngoscope blade, tracheal intubation is performed with the glottic opening viewed only by the fiberoptic stylet scope. 
Fig. 2. Tracheal intubation procedure. After lifting the tongue using a standard laryngoscope blade, tracheal intubation is performed with the glottic opening viewed only by the fiberoptic stylet scope. 
Fig. 2. Tracheal intubation procedure. After lifting the tongue using a standard laryngoscope blade, tracheal intubation is performed with the glottic opening viewed only by the fiberoptic stylet scope. 
×
Fig. 3. A view of the glottic opening through the fiberoptic stylet scope (FSS). This photograph was taken using a charge-coupled device camera attached to the eyepiece of the FSS. 
Fig. 3. A view of the glottic opening through the fiberoptic stylet scope (FSS). This photograph was taken using a charge-coupled device camera attached to the eyepiece of the FSS. 
Fig. 3. A view of the glottic opening through the fiberoptic stylet scope (FSS). This photograph was taken using a charge-coupled device camera attached to the eyepiece of the FSS. 
×
Fig. 4. Comparison of the time necessary for tracheal intubation using the new fiberoptic stylet scope among the groups divided according to the classes of Mallampati. There is no significant difference among the three groups. 
Fig. 4. Comparison of the time necessary for tracheal intubation using the new fiberoptic stylet scope among the groups divided according to the classes of Mallampati. There is no significant difference among the three groups. 
Fig. 4. Comparison of the time necessary for tracheal intubation using the new fiberoptic stylet scope among the groups divided according to the classes of Mallampati. There is no significant difference among the three groups. 
×
Table 1. Variables Concerning the Difficult Airway 
Image not available
Table 1. Variables Concerning the Difficult Airway 
×