Free
Education  |   October 2014
Noise in the Operating Room
Author Affiliations & Notes
  • Jonathan D. Katz, M.D.
    From the Department of Anesthesiology, Yale University School of Medicine, New Haven, Connecticut.
  • This article is featured in “This Month in Anesthesiology,” page 1A. The figure was created by Annemarie B. Johnson, C.M.I., Medical Illustrator, Vivo Visuals, Winston-Salem, North Carolina.
    This article is featured in “This Month in Anesthesiology,” page 1A. The figure was created by Annemarie B. Johnson, C.M.I., Medical Illustrator, Vivo Visuals, Winston-Salem, North Carolina.×
  • Submitted for publication January 4, 2014. Accepted for publication April 16, 2014.
    Submitted for publication January 4, 2014. Accepted for publication April 16, 2014.×
  • Address correspondence to Dr. Katz: Department of Anesthesiology, Yale University School of Medicine, 41 Island View Avenue, Branford, Connecticut 06405. jonathan.katz@yale.edu. Information on purchasing reprints may be found at www.anesthesiology.org or on the masthead page at the beginning of this issue. Anesthesiology’s articles are made freely accessible to all readers, for personal use only, 6 months from the cover date of the issue.
Article Information
Education / Clinical Concepts and Commentary / Cardiovascular Anesthesia / Central and Peripheral Nervous Systems / Patient Safety / Technology / Equipment / Monitoring
Education   |   October 2014
Noise in the Operating Room
Anesthesiology 10 2014, Vol.121, 894-898. doi:10.1097/ALN.0000000000000319
Anesthesiology 10 2014, Vol.121, 894-898. doi:10.1097/ALN.0000000000000319
As recently as the 1960s, hospitals were famous for their quiet and serene environment. Noise restrictions were zealously enforced internally by uniformed nurses and externally by street signs around the perimeter declaring “Hospital—Quiet Zone.”
Hospitals and especially operating rooms are no longer quiet.1  In 1972, before the introduction of much of the noisy equipment now routinely used during surgical procedures, it was observed that noise levels in operating rooms frequently exceed those of a busy highway.2  The authors labeled noise as the “third pollution” along with air and water pollution. Others have described the noise in critical care areas as equivalent to the cafeteria at noon and only slightly less noisy than in the boiler room.
More recent studies have reaffirmed the escalation of the noisy atmosphere of hospitals and operating rooms. Average noise levels commonly are greater than federal limits for occupational noise exposure and frequently exceed those considered a hazard to health.
Noise levels of this intensity have wide-spread implications for healthcare workers and their patients. In the following report, we will examine the common sources and possible consequences of excessive operating room noise and suggest some remedies.
Materials and Methods
A literature search was conducted during the period from October 2013 to January 2014 searching for the following terms: noise, noise pollution, occupational noise, auditory perception, hospital, operating room, and music. Searches were conducted using PubMed, Ovid, and Google Scholar. The reference lists of all articles discovered in these searches were examined for additional references.
Regulation of Occupational Noise
Several federal agencies, including the Occupational Safety and Health Administration, National Institute for Occupational Safety and Health, and the Environmental Protection Agency, have developed guidelines and recommendations for safe levels of noise in the workplace. These differ considerably in large part because of differences in the formulae used to determine harmful exposure. For example, the guidelines from the National Institute for Occupational Safety and Health are most conservative in that they begin with a time-weighted average of 85 decibels (A) (dBA) (the allowable continuous exposure for an 8-h work day) and use a 3-dBA time/intensity exchange rate in which the permissible time of exposure is halved for each 3 dBA increase in sound (the “3 dBA rule”)*01  (fig. 1). The limits established by the Occupational Safety and Health Administration begin at 90 dBA for an 8-h work day and use a 5-dBA exchange rate in recognition of the fact that in most workplaces interruptions in noise exposure occur throughout the day.†02  Specifically within hospitals, average noise levels of 45 dBA or less are recommended. Both National Institute for Occupational Safety and Health and Occupational Safety and Health Administration guidelines agree that the peak level for impulsive noise (characterized by a steep rise in the sound level to a high peak followed by a rapid decay) should not exceed 140 dBA.
Fig. 1.
A schematic illustration to show relative intensities of different noises and the acceptable time limits of exposure. The noise levels commonly experienced in a modern operating room frequently exceed limits for a workplace established by the National Institute for Occupational Safety and Health (NIOSH). Adapted, with permission, from the Centers for Disease Control and Prevention. Original graphic available at: http://www.cdc.gov/niosh/topics/noise/chart-lookatnoise.html. (Adaptions are themselves works protected by copyright. So in order to publish this adaption, authorization must be obtained both from the owner of the copyright in the original work and from the owner of copyright in the translation or adaption.)
A schematic illustration to show relative intensities of different noises and the acceptable time limits of exposure. The noise levels commonly experienced in a modern operating room frequently exceed limits for a workplace established by the National Institute for Occupational Safety and Health (NIOSH). Adapted, with permission, from the Centers for Disease Control and Prevention. Original graphic available at: http://www.cdc.gov/niosh/topics/noise/chart-lookatnoise.html. (Adaptions are themselves works protected by copyright. So in order to publish this adaption, authorization must be obtained both from the owner of the copyright in the original work and from the owner of copyright in the translation or adaption.)
Fig. 1.
A schematic illustration to show relative intensities of different noises and the acceptable time limits of exposure. The noise levels commonly experienced in a modern operating room frequently exceed limits for a workplace established by the National Institute for Occupational Safety and Health (NIOSH). Adapted, with permission, from the Centers for Disease Control and Prevention. Original graphic available at: http://www.cdc.gov/niosh/topics/noise/chart-lookatnoise.html. (Adaptions are themselves works protected by copyright. So in order to publish this adaption, authorization must be obtained both from the owner of the copyright in the original work and from the owner of copyright in the translation or adaption.)
×
These noise exposure regulations represent a compromise between practicality and hearing protection. They are not designed to protect every worker from experiencing any noise-induced hearing loss and they do not address other noise-associated health and performance hazards. Many authorities believe that a workplace noice limit of approximately 55 dBA would be necessary to ensure universally safe conditions.
Sources of Noise in the Operating Room
Noise within operating rooms comes from both staff and equipment. Staff-related activities and conversations are a major component of operating room noise and can produce noise levels as high as 78 dBA.3  Equipment-related noises as great as 120 dBA are caused by movement of equipment, clanging and dropping of metal instruments, and use of electric or air-powered surgical instruments, hammers, suction apparatus, anesthetic monitors, and alarms. Forced air warming units alone add as much as 84 dBA to the background noise (Jonathan D. Katz, M.D., Noise from forced air patient warming units. Unpublished data. Data collected in November, 2013).
The monitors in a modern operating room are host to a great many alarms and alerts which are commonly cited as the most intrusive of operating room noises. These alarms frequently provide extraneous, ambiguous, or false information that has no therapeutic significance. In one study conducted during cardiac surgery, there was an average of 359 ± 158 alarms (1.2 min−1), 80% of which had no therapeutic significance.4  All of these false alarms can desensitize the staff so that true alarms go unrecognized. In many cases, the alarms are so annoying and distracting that they are turned off. This practice is discouraged in the Standards for Basic Anesthetic Monitoring of the American Society of Anesthesiologists which suggest only “brief” interruptions of monitoring in “rare or unusual circumstances.”‡03 
Music is also a frequent contributor to operating room noise. The exact noise levels resulting from background music in operating rooms have not been quantitated but can be extrapolated from a report citing noise levels as high as 87 dBA that are commonly generated by music played on home audio equipment.5 
Noise Levels in Operating Rooms
Noise levels in operating rooms frequently exceed the limits established by federal regulatory agencies. In 1972, Shapiro and Berland2  reported noise levels as high as 85 dBA in the operating room during a routine cholecystectomy. Twenty years later, Hodge and Thompson6  reported intermittent sounds to 108 dBA during a “typical major surgical procedure.” Forty years after Shapiro’s report, Fritsch et al.7  reported noise levels as high as 131 dBA during simulated otolaryngeal surgery.
Operating rooms are noisy even when unoccupied due in part to their high-capacity air conditioning systems. Noise increases progressively with the entry of staff and patient. Once surgery commences, peak levels can exceed 120 dBA.8  Levels remain greater than 100 dBA for greater than 40% of the time during some particularly noisy procedures, such as orthopedics, neurosurgery, and extracorporeal shock wave lithotripsy. The beginning and the end of surgery, which coincide with anesthetic induction and emergence, are especially noisy periods.9  At these times, surgical equipment is being prepared or dismantled and conversations unrelated to direct patient care occur between staff members.
Impact of Noise Pollution in the Operating Room
Occupational Health
Exposure to occupational noise levels as low as 75 dBA can have both short- and long-term adverse effects on health.10  Predisposing individual factors such as age, comorbid medical conditions, medications, and lifetime total cumulative noise exposure also play a role in how and to what extent an individual responds to noise.
The most commonly reported health consequences of chronic exposure to high noise levels are tinnitus and hearing loss. The nature and severity of the hearing impairment is a direct function of the intensity and frequency of the sound pressure and duration and pattern of exposure.
There is growing evidence that nurses and surgeons who consistently work in noisy operating rooms are susceptible to noise-induced hearing loss.11  Substantial hearing loss has also been demonstrated among anesthesiologists. In a study conducted by Wallace et al.,12  66% of anesthesiologists had abnormal audiograms and those younger than 55 yr had a hearing acuity significantly worse than the general population.
Anesthetized patients may be particularly vulnerable to acoustic trauma after long exposure to noisy surgical equipment. Anesthetic drugs weaken the stapedius muscle, which normally contracts and protects the cochlea when exposed to loud sounds. In the absence of this protective reflex, hearing impairment may occur, especially among vulnerable populations such as the elderly.
Noise, especially unexpected high-intensity sounds, acts as a biologic stressor that can produce a startle reaction and activate the fight or flight response of the autonomic and endocrine systems. Chronic exposure to excessive noise has been associated with increases in heart rate, blood pressure, peripheral vascular resistance, and an increased prevalence of various forms of cardiovascular diseases, including hypertension, angina pectoris, myocardial infarction, and premature death.13 
Cognition
Chronic noise exposure, even at moderate intensity, can hamper psychomotor, intellectual, attention, and memory functions. This impairment is especially apparent when an individual is exposed to “irrelevant speech” while engaged in mental activities that rely heavily on working memory, such as during multitasking. The impact of this detrimental effect of noise on anesthesiologists was demonstrated in a study in which deterioration of mental efficiency and short-term memory was observed among anesthesia residents exposed to a recording of typical operating room noises.14 
Communication
One of the most harmful of the acute effects of noise pollution in the operating room is the interference it imposes on verbal communication. Communication among staff members is a key component of patient safety. However, communication failures during surgery are common and have been identified as one of the leading root causes of error and poor patient outcomes by The Joint Commission.§04  The ability of noise to disrupt operating room communication was demonstrated in a study in which the auditory processing functions of surgeons were significantly diminished by music and operating room noise.15 
Performance
Activities that require a high degree of information processing and concentration are particularly susceptible to the adverse effects of noise. There have been conflicting reports on the impact of noise on surgical performance, explained in part by variables in experimental design. The complexity of the task and the experience of the surgeon play a significant role in how noise affects surgical tasks.
There is little evidence to demonstrate a direct association between excessive operating room noise and poor surgical outcomes. In one study, a correlation was identified between increased sound levels during surgery and surgical-site infections.16  The authors hypothesized that the increased sound levels might be a surrogate marker indicating distraction or difficulty encountered during the procedure.
Anesthesiologists are especially affected by a noisy operating room because of their continuous presence in the room, their close proximity to noisy equipment, and the fact that the noisiest times occur during the critical anesthesia components of a case. In one study, 84% of anesthesiologists reported that the noise levels in their operating rooms negatively affected their work.17 
Nurses and other operating room personnel who work in close quarters with surgeons and anesthesiologists are subject to the same noise-induced handicaps.
Patient safety and comfort can be adversely affected by noise pollution. Noise is a top complaint among hospital patients and consistently gets the worst marks on Medicare patient surveys. In a study of patients undergoing elective surgery, 52% reported that it was noisy during the induction and/or emergence of anesthesia and 16% found the noise to be distressing.18  In addition, higher doses of propofol are necessary to achieve the desired bispectral index in a noisy operating room.19 
Music
Music is a special type of noise. Carefully selected music has a well-known calming effect during stressful situations. However, the role of music in the operating room remains controversial. Music can add 87 dBA or more to the already considerable ambient noise levels in the operating room.5  Depending on a number of circumstances, including coexistent environmental factors, personal taste, and the required task, an individual’s response to music can vary from soothed to distressed.
Music has variously been shown to have a positive, neutral, or negative effect on different measures of surgeons’ performance. In one frequently cited study, Allen and Blascovich20  found that autonomic reactivity was reduced and mental task performance increased in surgeons listening to self-selected music as compared with no music and to generic stress reduction background music. It is important to note that the volunteers in this study were all self-reported music enthusiasts, the music was self-selected, the study was conducted in a sound-proof laboratory, and the task tested was an arithmetic exercise.
Others have reported a detrimental effect of music on surgical performance, especially among less experienced surgeons. For example, in one randomized controlled trial of novice surgeons, music during training procedures was shown to cause distraction and impaired performance.21 
The impact of music on anesthesiologists is also unclear. Carefully selected and modulated music can improve vigilance and monitoring performance. However, many anesthesiologists feel that music can reduce the ease and accuracy of performing their tasks. In one study, 26% of anesthesiologists felt that music reduced their vigilance and impaired their communication with other staff and 51% felt that music was distracting when a problem was encountered.22  Seventy-eight percent felt that music that they disliked was the most distracting. On the contrary, a subsequent study by the same group failed to identify any adverse effect of self-selected or classical music on psychomotor tests (testing numeric vigilance, tracking, and reaction time) performed by residents in anesthesiology.23 
Patients are also affected by music in the operating room. Carefully selected music can have an anxiolytic and sedative effect on patients before, during, and after surgery. This beneficial effect seems to be independent of the additional advantage provided by blocking out ambient operating room noises.24 
For all personnel in the operating room, it is apparent that the selection of the music and the manner in which it is delivered play a key role in its effect.
Suggested Remedies
The adverse effects of noise pollution can be ameliorated by either blocking the production of the noise or the entry of noise into the ear. The easiest and most effective solution is to minimize the noise production.
Because the operating room staff is the source of a large component of the noise pollution, efforts can be directed toward minimizing irrelevant conversation, especially during critical times. One approach that has been advocated is to adapt a “sterile cockpit” environment, as used in the aviation industry, which also requires use of standardized nomenclature and a structured format for communication.25 
A second approach is to develop a behavior modification program to educate staff members about the sources and potential harm of noise pollution. This educational program should focus on common and easily remedied sources of extraneous operating room noise. The effectiveness of this approach has been demonstrated on acute inpatient hospital wards and in intensive care units.26 
Consideration should be given to noise when decisions are made concerning supplies and operating room design. Noisy equipment such as speakers should be placed as far as possible from the anesthetizing location. Substitution of plastic bowls and trays for metallic ones can minimize noise from clanging of these implements. Installation of sound insulation and avoidance of sound-reflective floor, wall, and ceiling surfaces would be significant factors in limiting echoing and reverberation of unavoidable noises.
Conclusion
The noise levels in hospitals and operating rooms are consistently above the limits established by federal regulatory agencies, in many cases by as much as 40 dBA. These noise levels have been associated with adverse consequences on the health and performance of staff and on patient safety. Much of this noise is generated by operating room personnel and is avoidable. Some corrective measures can be taken at little expense and inconvenience to staff. Additional research is needed to identify materials and design to further limit equipment-related noise.
Acknowledgments
Support was provided solely from institutional and/or departmental sources.
Competing Interests
The author declares no competing interests.
*National Institute for Occupational Safety and Health. Criteria for a recommended standard: Occupational noise exposure. Revised criteria 1998. Available at: http://www.cdc.gov/niosh/docs/98-126/pdfs/98-126.pdf. Accessed August 27, 2014.
National Institute for Occupational Safety and Health. Criteria for a recommended standard: Occupational noise exposure. Revised criteria 1998. Available at: http://www.cdc.gov/niosh/docs/98-126/pdfs/98-126.pdf. Accessed August 27, 2014.×
U.S. Department of Labor. Occupational Noise Exposure.29 CFR x1910.95. Available at: http://www.osha.gov/dts/osta/otm/noise/standards.html. Accessed December 23, 2013.
U.S. Department of Labor. Occupational Noise Exposure.29 CFR x1910.95. Available at: http://www.osha.gov/dts/osta/otm/noise/standards.html. Accessed December 23, 2013.×
American Society of Anesthesiologists, Standards for Basic Anesthetic Monitoring. Last Amended October 20, 2010. Available at: http://www.asahq.org. Accessed December 23, 2013.
American Society of Anesthesiologists, Standards for Basic Anesthetic Monitoring. Last Amended October 20, 2010. Available at: http://www.asahq.org. Accessed December 23, 2013.×
§The Joint Commission. Sentinel Event Data: Root Causes by Event Type. 2011. Available at: http://www.jointcommission.org/Sentinel_Event_Statistics/. Accessed December 23, 2013.
The Joint Commission. Sentinel Event Data: Root Causes by Event Type. 2011. Available at: http://www.jointcommission.org/Sentinel_Event_Statistics/. Accessed December 23, 2013.×
References
Grumet, GW Pandemonium in the modern hospital.. N Engl J Med. (1993). 328 433–7 [Article] [PubMed]
Shapiro, RA, Berland, T Noise in the operating room.. N Engl J Med. (1972). 287 1236–8 [Article] [PubMed]
Shankar, N, Malhotra, KL, Ahuja, S, Tandon, OP Noise pollution: A study of noise levels in the operation theatres of a general hospital during various surgical procedures.. J Indian Med Assoc. (2001). 99 244, 246–7
Schmid, F, Goepfert, MS, Kuhnt, D, Eichhorn, V, Diedrichs, S, Reichenspurner, H, Goetz, AE, Reuter, DA The wolf is crying in the operating room: Patient monitor and anesthesia workstation alarming patterns during cardiac surgery.. Anesth Analg. (2011). 112 78–83 [Article] [PubMed]
Gloag, D Noise and health: Public and private responsibility.. Br Med J. (1980). 281 1404–6 [Article] [PubMed]
Hodge, B, Thompson, JF Noise pollution in the operating theatre.. Lancet. (1990). 335 891–4 [Article] [PubMed]
Fritsch, MH, Chacko, CE, Patterson, EB Operating room sound level hazards for patients and physicians.. Otol Neurotol. (2010). 31 715–21 [Article] [PubMed]
Kracht, JM, Busch-Vishniac, IJ, West, JE Noise in the operating rooms of Johns Hopkins Hospital.. J Acoust Soc Am. (2007). 1215 Pt1 2673–80 [Article] [PubMed]
Ginsberg, SH, Pantin, E, Kraidin, J, Solina, A, Panjwani, S, Yang, G Noise levels in modern operating rooms during surgery.. J Cardiothorac Vasc Anesth. (2013). 27 528–30 [Article] [PubMed]
Stansfeld, SA, Matheson, MP Noise pollution: Non-auditory effects on health.. Br Med Bull. (2003). 68 243–57 [Article] [PubMed]
Willett, KM Noise-induced hearing loss in orthopaedic staff.. J Bone Joint Surg Br. (1991). 73 113–5 [PubMed]
Wallace, MS, Ashman, MN, Matjasko, MJ Hearing acuity of anesthesiologists and alarm detection.. Anesthesiology. (1994). 81 13–28 [Article] [PubMed]
Gan, WQ, Davies, HW, Demers, PA Exposure to occupational noise and cardiovascular disease in the United States: The National Health and Nutrition Examination Survey 1999–2004.. Occup Environ Med. (2011). 68 183–90 [Article] [PubMed]
Murthy, VS, Malhotra, SK, Bala, I, Raghunathan, M Auditory functions in anaesthesia residents during exposure to operating room noise.. Indian J Med Res. (1995). 101 213–6 [PubMed]
Way, TJ, Long, A, Weihing, J, Ritchie, R, Jones, R, Bush, M, Shinn, JB Effect of noise on auditory processing in the operating room.. J Am Coll Surg. (2013). 216 933–8 [Article] [PubMed]
Kurmann, A, Peter, M, Tschan, F, Mühlemann, K, Candinas, D, Beldi, G Adverse effect of noise in the operating theatre on surgical-site infection.. Br J Surg. (2011). 98 1021–5 [Article] [PubMed]
Tsiou, C, Efthymiatos, G, Katostaras, T Noise in the operating rooms of Greek hospitals.. J Acoust Soc Am. (2008). 123 757–65 [Article] [PubMed]
Liu, EH, Tan, S Patients’ perception of sound levels in the surgical suite.. J Clin Anesth. (2000). 12 298–302 [Article] [PubMed]
Kim, DW, Kil, HY, White, PF The effect of noise on the bispectral index during propofol sedation.. Anesth Analg. (2001). 93 1170–3 [Article] [PubMed]
Allen, K, Blascovich, J Effects of music on cardiovascular reactivity among surgeons.. JAMA. (1994). 272 882–4 [Article] [PubMed]
Miskovic, D, Rosenthal, R, Zingg, U, Oertli, D, Metzger, U, Jancke, L Randomized controlled trial investigating the effect of music on the virtual reality laparoscopic learning performance of novice surgeons.. Surg Endosc. (2008). 22 2416–20 [Article] [PubMed]
Hawksworth, C, Asbury, AJ, Millar, K Music in theatre: Not so harmonious. A survey of attitudes to music played in the operating theatre.. Anaesthesia. (1997). 52 79–83 [Article] [PubMed]
Hawksworth, CR, Sivalingam, P, Asbury, AJ The effect of music on anaesthetists’ psychomotor performance.. Anaesthesia. (1998). 53 195–7 [Article] [PubMed]
Ayoub, CM, Rizk, LB, Yaacoub, CI, Gaal, D, Kain, ZN Music and ambient operating room noise in patients undergoing spinal anesthesia.. Anesth Analg. (2005). 100 1316–9 [Article] [PubMed]
Broom, MA, Capek, AL, Carachi, P, Akeroyd, MA, Hilditch, G Critical phase distractions in anaesthesia and the sterile cockpit concept.. Anaesthesia. (2011). 66 175–9 [Article] [PubMed]
Kahn, DM, Cook, TE, Carlisle, CC, Nelson, DL, Kramer, NR, Millman, RP Identification and modification of environmental noise in an ICU setting.. Chest. (1998). 114 535–40 [Article] [PubMed]
Fig. 1.
A schematic illustration to show relative intensities of different noises and the acceptable time limits of exposure. The noise levels commonly experienced in a modern operating room frequently exceed limits for a workplace established by the National Institute for Occupational Safety and Health (NIOSH). Adapted, with permission, from the Centers for Disease Control and Prevention. Original graphic available at: http://www.cdc.gov/niosh/topics/noise/chart-lookatnoise.html. (Adaptions are themselves works protected by copyright. So in order to publish this adaption, authorization must be obtained both from the owner of the copyright in the original work and from the owner of copyright in the translation or adaption.)
A schematic illustration to show relative intensities of different noises and the acceptable time limits of exposure. The noise levels commonly experienced in a modern operating room frequently exceed limits for a workplace established by the National Institute for Occupational Safety and Health (NIOSH). Adapted, with permission, from the Centers for Disease Control and Prevention. Original graphic available at: http://www.cdc.gov/niosh/topics/noise/chart-lookatnoise.html. (Adaptions are themselves works protected by copyright. So in order to publish this adaption, authorization must be obtained both from the owner of the copyright in the original work and from the owner of copyright in the translation or adaption.)
Fig. 1.
A schematic illustration to show relative intensities of different noises and the acceptable time limits of exposure. The noise levels commonly experienced in a modern operating room frequently exceed limits for a workplace established by the National Institute for Occupational Safety and Health (NIOSH). Adapted, with permission, from the Centers for Disease Control and Prevention. Original graphic available at: http://www.cdc.gov/niosh/topics/noise/chart-lookatnoise.html. (Adaptions are themselves works protected by copyright. So in order to publish this adaption, authorization must be obtained both from the owner of the copyright in the original work and from the owner of copyright in the translation or adaption.)
×